|
Electronic Journal of Biotechnology, Vol. 13, No. 1, Jan, 2010 Research Article Enhancement of wanlongmycin production by nitrogen ion beam implantation Xiaoyong Zhang1 , Birun Lin*2, Xiangyang Gao3, Huifang Shen4 1Plant Protection Research Institute,
Guangdong Academy of Agricultural Science and
Chengdu Institute of Biology,
Chinese Academy of Sciences,
PR China Financial support: National Natural Science Foundation of China (No. 30471161) and the Guangdong Natural Science Foundation of China (No. 8151064001000010 and No.06025388). Code Number: ej10003 Abstract In an attempt to obtain an industrial strain with higher yield of wanlongmycin, the wild strain Streptomyces griseovariabilis GAAS2507 was mutated by a novel mutagen, nitrogen ion beam with energy of 20 kilo electron volts (KeV) and dose ranging from 7.80 x 1014 to 2.86 x 1015 ions/cm2. One mutant strain WN939 was obtained. Its yield of wanlongmycin reached 271.24 µg/mL, which was 82.10% higher than that of the wild strain. The mutant strain WN939 was relatively stable for the production of wanlongmycin through six successive transfers of cultures and a repeat fermentation in a 30 L fermentor. In addition, the mutant strains were investigated and divided into five types by their colony phenotypes and production of wanlongmycin. Among them, three types mutant strains exhibited positive mutation, while the other two types mutant strains exhibited negative mutation. Keywords: mutagen nitrogen ion beam implantation, Streptomyces griseovariabilis GAAS2057, wanlongmycin.
Many agricultural losses are due to plant diseases, insect pests and herb pest; bio-pesticide has become a tendency and a goal of global pesticide development because of its relatively low side-effects and friendliness to environment (Liu and Yao, 2004). In 1996, a new actinomycete strain was isolated by our laboratory from a soil sample collected in Malaysia. It could produce a novel agricultural antibiotic which had a strong activity against a lot of plant oomyces diseases. The novel agricultural antibiotic was named wanlongmycin and believed to be a new member of quinoxaline-like antibiotics by structural identification. Due to low productivity of wanlongmycin, it is urgent that the original strain should be mutated and screened to obtain an industrial high-yield strain. Muller (1927), the father of radiation genetics, found that X-ray radiation could increase mutation rate. After the ground breaking work of Muller, a great number of studies on mutagenic methods have been established and developed for microbe, plant and animal breeding, including γ-rays, ultraviolet, alpha particles, beta particles, neutron, etc. However more efforts are still being tried to search for better methods with a higher mutation rate and wider mutation spectra. In 1989, the mutagenicity of low energy ions on rice was firstly reported in China (Yu et al. 1989). Through exploring the mutagenic effect for years, it was found that this approach possesses a higher mutation rate and a wider mutational spectrum with a higher survival rate (Yu, 1999; Yang et al. 2007). In the study of the mutational mechanisms of low energy ion beam radiation, researchers had proposed that the interaction between low energy ion beam and the organism included energy deposition, momentum transferring, mass deposition and charge exchange (Yu, 2000). Low energy ion beam had a wide range of biological effects, including extracellular and intracellular DNA damage (Zhao et al. 2003), amino acid and nucleotide decomposition (Shi et al. 2001), inactivation of viruses and microbes (Du et al. 1999) and aberrant chromosomes in wheat (Wu and Yu, 2001). Although these propositions are still not completely understood, and much research has been studied in depth, the applications of low energy ion beam implantation are to be expanded to serve effectively and profitably for developments of agriculture and biotechnical industries (Gu et al. 2008). Since the 1980s, several new varieties and more than 3000 breeding materials have been bred by ion beam implantation in China (Xu et al. 2004). However, ion beam implantation is used in mutational breeding of wanlongmycin-producing micro-organisms for the first time. Here, we mainly investigated the mutagenic effect of nitrogen ion beam implantation on improving the production of wanlongmycin by Streptomyces griseovariabilis GAAS2507. Materials and Methods Wanlongmycin-producing strain Streptomyces griseovariabilis GAAS2507 (which is abbreviated to strain GAAS2507) is described here and has been deposited in the China Center for Type Culture Collection (CCTCC). Bacillus subtilis MIG1.22 was obtained from the Plant Protection Research Institute, Guangdong Academy of Agricultural Science, China. Seed medium: soluble starch 2%, KNO3 0.1%, K2HPO4 0.05%, NaCl 0.05%, FeSO4 0.001%, MgSO4·7H2O 0.005%, agar 1.5%, pH 7.2. Fermentation medium: glucose 1%, corn syrup 1.5%, peptone 0.5%, NaCl 0.5%, CaCO3 0.05%, (NH4)2SO4 0.05%, pH 7.2. BS medium for growth of B. subtilis: glucose 0.3%, peptone 0.3%, K2HPO4 0.4%, agar 1.5%, pH 7.2. Strain GAAS2507 and its mutant strains that had been incubated on seed medium at 28ºC for 10 days were inoculated from the seed medium to a 500 mL flask containing 100 mL of fermentation medium and incubated in a rotary shaker at a speed of 200 r/min at 32ºC for 5 days. The mutant strain with the highest yield of wanlongmycin, after incubation on seed medium at 28ºC for 10 days, was inoculated from seed medium to a 30 L jar fermentor (Biostat B) containing 20 L of fermentation medium, and incubated at 30ºC for 72 hrs, with an aeration rate of 0.6-0.8 vvm and agitation at 300-500 r/min. B. subtilis was incubated on BS medium at 37ºC for 12 hrs. Nitrogen ion beam implantation Implantation sources were produced by the ion beam bioengineering instrument that was devised by the Chinese Academy of Sciences, Institute of Plasma Physics. Samples (0.1 mL) of strain GAAS2507 spore suspension (1 x 108 spores/mL) were spread to form a single-cell layer on a sterile plate and dried in an extraction hood. The plate was implanted by the nitrogen ion beam with energy of 20 kilo electron volts (KeV) and different doses (7.80 x 1014 - 2.86 x 1015 ions/cm2). The operating pressure in the target chamber was about 10-3 Pa. The plates were placed in pairs sequentially in the target chamber. The upper plate was exposed to ion beam implantation, while the lower plate was unexposed and treated as a control. After implantation, every treated plate and control plate were washed with 1 mL of sterile distilled water (Liu et al. 2006). Extraction and determination of wanlongmycin Extraction and determination of wanlongmycin in fermentation broth had been described by Zhang et al. (2006). Briefly, the cultures were centrifuged at 10000 r/min for 10 min to remove supernatant, and the cells were washed with distilled water three times, then the washed cells were extracted with 60% aqueous acetone solution for 2 hrs. After extracted solution was centrifuged at 10000 r/min for 10 min, the supernatant was filtrated by 0.45-µm-pore-size millipore filter and was injected into a HPLC (Symmetry 5 μm C18 column, 3.9 x 150 mm, Waters, USA). The mobile phase was methanol-water 20:80 (v/v) which was pumped at a flow rate of 1.0 ml/min and the elution pattern was monitored at 280 nm. Results and Discussion Both the dose and the energy level of ion implantation influenced the mutation spectra, and different micro-organisms were sensitive to different combinations of these two parameters (Zhou et al. 2005). Strain GAAS2507 was implanted by the nitrogen ion beam with energy of 20 KeV and different doses (7.80 x 1014, 1.30 x 1015, 1.82 x 1015, 2.34 x 1015, and 2.86 x 1015 ions/cm2). Figure 1 was the curve of relationship between the survival rate of GAAS2507 and the dose of nitrogen ion beam implantation. When the implantation of dose lower than 1.82 x 1015 ions/cm2, the survival rate dropped slowly; while when the dose exceed 1.82 x 1015 ions/cm2, the survival rate increased sharply. But as the dose surpassed 2.34 x 1015 ions/cm2, the survival rate decreased more significantly again. The “down-up-down” pattern curve (also was called “saddle” shape) was consistent with other reports in ion beam implantation (Li et al. 2005a), which differed from exponential curves caused by microwave and ultraviolet irradiation (Li et al. 2003). Recently, a great number of studies have indicated that the interaction of low energy ions and biological material is more complicated than that of γ-ray or X-ray radiation with organisms (Yuan et al. 2007). Several models have been proposed to explain the “down-up-down” pattern curve, but the mechanisms have not been clarified yet (Song and Yu, 2000). Mutagenic effects induced by nitrogen ion beam implantation The positive mutation rate induced by nitrogen ion beam implantation is shown in Figure 2. The positive mutation rate had close relationship with implantation dose. When the implantation dose was 2.34 x 1015 ions/cm2, the highest positive mutation rate (reached 39.61%) was achieved, which showed the wide mutation spectrum. The implantation dose of wide mutation spectrum fit the saddle part in the survival curve well. Usually, the highest mutation rate was obtained when the survival rate of the microorganism was 20~30% (Su et al. 2006). The results of positive mutation rate by nitrogen ion beam implantation in our experiments validate this viewpoint. Under the conditions of 2.34 x 1015 ions/cm2 implantation dose, one mutant strain WN939 was obtained with a wanlongmycin yield of 271.24 µg/mL, which was 82.10% higher than that of the strain GAAS2507. In order to ascertain whether it could produce wanlongmycin stably, the mutant strain WN939 was cultivated by flask fermentation for successive generations. Figure 3 showed the wanlongmycin concentration of the second and third generation by flask fermentation decreased slightly; however, the production of the fourth, fifth and sixth generation tended to be stable. Besides, a repeat fermentation was done in a 30 L fermentor for verification of the stability of the mutant strain WN939. The results (data not shown) indicated the maximum concentration of wanlongmycin in the fermentation processes reached 274.24 µg/mL. Both the results showed that the mutant strain WN939 was able to maintain a high yield of wanlongmycin over successive generations. It had been reported that ionizing radiation could cause a large variety of changes in essential components of cell (Kiefer et al. 1996). In this study, five types of mutant strains (defined as mutant type A, B, C, D, and E strains) were obtained at an energy level of 20 KeV and dose of 2.34 x 1015 ions/cm2, which showed a lot of differences from the wild type strain in colony morphology (Figure 4). Lots of studies suggested that nitrogen ion beam implantation was as different from traditional mutant method, such as X-ray and reagent of chemical mutation, because it has effects of mass deposition and charged ion exchange in addition to energy absorption (Li et al. 2005b). Accumulating evidence has shown nitrogen ion implantation technology is a synthesis mutant method including some characteristic of physical and chemical mutation (Yu, 2000). Table 1 showed the correlation between the changes of colony morphology and production of wanlongmycin, which suggested most mutant type A, B and C strains exhibited positive mutation, while most mutant type D and E strains exhibited negative mutation. The mutant strain WN939, with the highest yield of wanlongmycin, belonged to mutant type A strain. Concluding Remarks Nitrogenion beam implantation, characterized by efficiency, safety and non-pollution, seems to be a good way to stimulate the wanlongycin production. The mutant strain WN939 obtained by nitrogenion beam implantation, is 82.10% higher yield than that of the wild strain GAAS2507 and is able to perform stably in batch fermentation. Five types of mutant strains, isolated under the condition of the energy level of 20 KeV and dose of 2.34 x 1015 ions/cm2, show a lot of differences from the wild type strain including the production of wanlongmycin and colony morphology. On the basis of the correlation between the colony morphology and the level of wanlongmycin production of mutant strains, a fast and effective method of screening wanlongmycin high-yield strains has been developed in here, which provides a good foundation for further investigation and research on screening industrial strains with higher yield of wanlongmycin. Acknowledgments The authors are grateful to Pref. Wu Yuejin of Key Laboratory of Ion Beam Bioengineering, Chinese Academy of Sciences, China, for his kindness in facilitating the ion beam bioengineering instrument. References
Note: Electronic Journal of Biotechnology is not responsible if on-line references cited on manuscripts are not available any more after the date of publication. Supported by UNESCO / MIRCEN network Copyright © 2010 by Pontificia Universidad Católica de Valparaíso -- Chile The following images related to this document are available:Photo images[ej10003t1.jpg] [ej10003f1.jpg] [ej10003f2.jpg] [ej10003f3.jpg] [ej10003f4.jpg] |
|